东柏地坪 专注工业地坪十五年

混凝土地面平整度不达标如何做环氧地坪漆?

环氧地坪漆是施工在混凝土表面上一层薄薄的涂料,厚度一般在0.5mm-3mm左右,因此,环氧地坪漆并不能改变地面的平整度,基本上混凝土地面平整度怎么样,做出来的效果就是怎样。那么,混凝土地面平整度达到什么要求做出来的环氧地坪漆才美观平整呢?

微信号:dgsmei
感谢你的信任 盼愉快合作
复制微信号

Epoxy floor paint is a thin layer of paint applied on the surface of concrete. Its thickness is generally about 0.5mm-3mm. Therefore, epoxy floor paint can not change the smoothness of the ground. Basically, how about the smoothness of the concrete floor, and what is the effect? So, what is the requirement of concrete floor smoothness to make epoxy floor paint to be beautiful and smooth? 

环氧地坪漆对混凝土地面平整度要求:

The requirements of epoxy floor paint for concrete surface smoothness are as follows:

根据不用的地面有不同的标准,但就大多数而言,基面平整度在2m范围之内,并且落差不能超过2mm.

There are different standards according to the unused ground, but for the most part, the smoothness of the base surface is within 2 meters and the drop can not exceed 2 m M.

混凝土地面平整度超出要求解决办法:

The concrete surface smoothness exceeds the required solution:

1、落差在5mm以内。混凝土基面平整度在5mm以内,可以使用下面两种解决方案。方案1:打磨机打磨找平。使用环氧地坪打磨机,或洗地打磨机配置金刚磨头进行基面打磨,将高出点打磨到与低点平行。方案2:刮砂。此法只能用于较厚的环氧地坪漆种类,如环氧砂浆地坪。在环氧地坪漆施工工艺中涂刮砂这道工序时,以地坪漆与石英砂进行混合,填充混凝土基面基面,实现找平的效果。

1. The drop is within 5 mm. The flatness of concrete foundation is less than 5 mm. The following two solutions can be used. Scheme 1: Grinding leveling by grinding machine. Use floor grinder, or wash ground grinder with diamond grinder to grind the base surface, grinding the high point to parallel with the low point. Scheme 2: Sand scraping. This method can only be used for thicker types of floor paint, such as epoxy mortar floor. In the process of scraping sand in the construction of epoxy floor paint, the floor paint is mixed with quartz sand to fill the base surface of concrete to achieve leveling effect.

2、落差在5mm以上。混凝土基面平整度在5mm以上,那用打磨机进行找平,或用环氧树脂地坪漆中涂刮砂找平成本将是巨大的,而且砂层厚度过高会对地坪漆性能造成一定影响。在落差在5mm以上的混凝土基面,重新施工3-5cm的水泥砂浆层,重新原浆收光,找平最好。

2. The drop is more than 5 mm. If the smoothness of concrete base is more than 5 mm, the cost of leveling with grinder or scraping sand in epoxy floor paint will be huge, and the high thickness of sand layer will have a certain impact on the performance of floor paint. In the concrete foundation with a drop of more than 5 mm, the cement mortar layer of 3-5 cm should be re-constructed, and the original mortar should be re-lightened, so that the leveling is the best.

复制成功

微信号: dgsmei
感谢你的信任 盼愉快合作

我知道了
微信号:dgsmei添加微信
dgsmei